Failure modes and process of tunnels reinforced by rockbolts under top explosion
WANG Guang-yong1,2,3,GU Jin-cai3,CHEN An-min3,XU Jing-mao3,ZHANG Xiang-yang3
1. Opening Project of Key Laboratory of Deep Mine Construction,Henan Polytechnic University, Jiaozuo 454000, China; 2. Department of Modern Mechanics,University of Science and Technology of China, Hefei 230026, China; 3. The Third Research Institute of the Corps of Engineers,General Staff of PLA, Luoyang 471023, China
Abstract：Based on model tests and numerical analysis, failure modes and process under top explosion are studied. According to the results of the model tests, the tunnels reinforced by rockbolts under top explosion have four kinds of failure modes, that is tensile failure, shearing failure, compressive failure, compressive and shearing failure. By analyzing the experimental profile and the propagation rules of stress waves, when the stress waves reach the surface of the tunnel, spalling failure will appear, which may make similar half elliptical rock mass peel off. Both sides of the tunnel produce cracks easily. With the increase of blast load, if the anchor reinforcement strength is weak, local collapse will appear, and once the intensity of anchorage zone is large, it will lead to collapse of the tunnel from spandrel to explosion center. Finally, in accordance with the action process of stress waves, the stress distribution and the development process of plastic zone, failure modes and process are further discussed through numerical analysis.
王光勇,顾金才,陈安敏,徐景茂,张向阳. 锚固洞室在顶爆作用下破坏形式及破坏过程研究[J]. 岩土工程学报, 2015, 37(8): 1381-1389.
WANG Guang-yong,GU Jin-cai,CHEN An-min,XU Jing-mao,ZHANG Xiang-yang. Failure modes and process of tunnels reinforced by rockbolts under top explosion. Chinese J. Geot. Eng., 2015, 37(8): 1381-1389.
[1] 曾宪明, 陈肇元. 锚固类结构安全性与耐久性问题探讨[J].岩石力学与工程学报, 2004, 23(13): 2235-2242. (ZENG Xian-ming, CHEN Zhao-yuan. Research on safety and durability of bolt and cable-supportal structures[J]. Chinese Journal of Rock Mechanics and Engineering, 2004, 23(13): 2235-2242. (in Chinese)) [2] 程良奎. 岩土锚固研究新进展[J]. 岩石力学与工程学报, 2005, 24(21): 3803-3811. (CHENG Liang-kui. Research and new progress in ground anchorage[J]. Chinese Journal of Rock Mechanics and Engineering, 2005, 24(21): 3803-3811. (in Chinese)) [3] 方从严, 卓家寿. 锚杆加固机制的试验研究现状[J]. 河海大学学报 (自然科学版), 2005, 33(6): 696-700. (FANG Cong-yan, ZHOU Jia-shou. Experimental study of status of rock bolts reinforcement mechanism[J]. Journal of Hohai University (Natural Science), 2005, 33(6): 696-700. (in Chinese)) [4] 张向阳, 顾金才, 沈 俊, 等. 爆炸荷载作用下洞室变形与锚杆受力分析[J]. 地下空间与工程学报, 2012, 8(4): 678-684. (ZHANG Xiang-yang, GU Jin-cai, SHEN Jun, et al. Tunnel deformation and bolt bearing state under explosion load[J]. Chinese Journal of Underground Space and Engineering, 2012, 8(4): 678-684. (in Chinese)) [5] 杨苏杭, 梁 斌, 顾金才, 等. 锚固洞室抗爆模型试验锚索预应力变化特性研究[J]. 岩石力学与工程学报, 2006, 25(增刊2): 3749-3756. (YANG Su-hang, LIANG Bin, GU Jin-cai, et al. Research on characteristics of prestress change of anchorage cable in anti-explosion model test of anchored cavern[J]. Chinese Journal of Rock Mechanics and Engineering, 2006, 25(S2): 3749-3756. (in Chinese)) [6] 顾金才, 陈安敏, 徐景茂, 等. 在爆炸荷载条件下锚固洞室破坏形态对比试验研究[J]. 岩石力学与工程学报, 2008, 27(7): 1315-1320. (GU Jin-cai, CHEN An-min. XU Jing-mao, et al. Model test study of failure patterns of anchored tunnel[J]. Chinese Journal of Rock Mechanics and Engineering, 2008, 27(7): 1315-1320. (in Chinese)) [7] 杨自友. 锚固洞室的抗爆性能研究[D]. 合肥: 中国科学技术大学, 2008. (YANG Zi-you. Study on the anti-detonating characteristics of underground opening reinforced by rockbolts[D]. Hefei: University of Science & Technology of China, 2008. (in Chinese)) [8] 张亮亮. 抗爆洞室不同部位预应力锚索受力特征研究[D]. 武汉: 武汉理工大学, 2009. (ZHANG Liang-liang. Study on stress character of prestressed anchorage in different regional antiknock chamber effected[D]. Wuhan: Wuhan University of Technology, 2009. (in Chinese)) [9] 余永强, 顾金才, 杨小林, 等. 动载下洞室加固锚杆受力的实验研究[J]. 兵工学报, 2009, 30(增刊2): 263-266. (YU Yong-qiang, GU Jin-cai, YANG Xiao-lin, et al. Experimental study on applied force of reinforcement cavity rock bolts under dynamic loading conditions[J]. Acta Armamentarii, 2009, 30(S2): 263-266. (in Chinese)) [10] 马海春.锚固洞室抗爆能力现场实验研究[D]. 合肥: 中国科学技术大学, 2011. (MA Hai-chun. Research on explosion resistinhg capacity site tests of underground cavern reinforced by grouted rockbolts[D]. Hefei: University of Science & Technology of China, 2011. (in Chinese)) [11] 徐景茂, 顾金才, 陈安敏, 等. 锚杆长度和间距对洞室抗爆性能影响研究[J]. 岩土力学, 2012, 33(1): 3489-3496. (XU Jing-mao, GU Jin-cai, CHEN An-min, et al. Study of anti-explosion ability of reinforced tunnels with different anchor lengths and spacings[J]. Rock and Soil Mechanics, 2012,33(1): 3489-3496. (in Chinese)) [12] 徐景茂, 顾金才, 陈安敏, 等. 拱脚局部加长锚杆锚固洞室抗爆模型试验研究[J]. 岩石力学与工程学报, 2012, 31(11): 2182-2186. (XU Jing-mao, GU Jin-cai, CHEN An-min, et al. Model test study of anti-explosion capacity of anchored tunnel with local lengthening anchors in arch springing[J]. Chinese Journal of Rock Mechanics and Engineering, 2012, 31(11): 2182-2186. (in Chinese)) [13] 单仁亮, 周纪军, 夏 宇, 等. 爆炸荷载下锚杆动态响应试验研究[J]. 岩石力学与工程学报, 2011, 30(8): 1540-1546. (SHAN Ren-liang, ZHOU Ji-jun, XIA Yu, et al. Experimental investigation on dynamic response of rockbolt under blasting load[J]. Chinese Journal of Rock Mechanics and Engineering, 2011, 30(8): 1540-1546. (in Chinese)) [14] 周纪军. 爆炸动载对近区锚杆支护结构影响的试验研究[D]. 北京: 中国矿业大学, 2011. (ZHOU Ji-jun. Effects of blast loading on rockbolt anchorage structure near the working face in the model test[D]. Beijing: China University of Mining & Technology, 2011. (in Chinese)) [15] ZHANG C S, ZOU D H, MADENGA V. Numerical simulation of wave propagation in grouted rock bolts and the effects of mesh density and wave frequency[J]. International Journal of Rock Mechanics & Mining Sciences, 2006(43): 634-639. [16] TANNANT D D, BRUMMER R K, YI X. Rockbolt behaviour under dynamic loading- field tests and modelling[J]. Int J Rock Mech Min Sci &Geomech Abstr, 1995, 32(6): 537-550. [17] GISLE S, ARNE M. The Influence of blasting on grouted rockbolts[J]. Tunneling and Underground Space Technology, 1998, 13(1): 65-70. [18] ORTLEPP W D, STACEY T R. Performance of tunnel support under large deformation static and dynamic loading[J]. Tunnelling and Underground Space Technology, 1998, 13(1): 15-21. [19] ANA Ivanovic, RICHARD D Neilson, et al. Influence of prestress on the dynamic response of ground anchorages[J]. Journal of Geotechnical and Geoenvironmental Engineering, 2002, 128(3): 237-249. [20] ANA Ivanovic, ANDY Starkey, RICHARD D. Neilson, et al. The influence of load on the frequency response of rock bolt anchorage[J]. Advances in Engineering Software, 2003, 34: 697-705. [21] RAJMENY P K, SINGHB U K, SINHA B K P. Predicting rock failure around boreholes and drives adjacent to stopes in Indian mines in high stress regions[J]. International Journal of Rock Mechanics & Mining Sciences, 2002, 39(2): 151-164. [22] SINGH P K. Blast vibration damage to underground coal mines from adjacent open-pit blasting[J]. International Journal of Rock Mechanics & Mining Sciences, 2002, 39(8): 959-973. [23] HAGEDORN H. Dynamic rock bolt test and UDEC simulation for a large carven under shock load[C]// Proceeding of International UDEC/3DEC Symposium on Numerical Modeling of Discrete Materialsin Geotechnical Engineering, Civil Engineering, and Earth Sciences. Bochum, 2004: 191-197. [24] 王礼力. 应力波基础[M]. 北京: 国防工业出版社, 2005. (WANG Li-li. Foundation of stress waves[M]. Beijing: National Defense Industry Press, 2005. (in Chinese)) [25] DENG X F, ZHU J B, CHEN S G, et al. Numerical study on tunnel damage subject to blast-induced shock wave in jointed rock masses[J]. Tunnelling and Underground Space Technology, 2014, 43: 88-100.
